NHTSA Issues Recalls Affecting Grand Design, Forest River, Gulf Stream

National Highway Traffic Safety Administration

The National Highway Traffic Safety Administration (NHTSA) has issued the following recalls:

Grand Design RV

Supply Line To Refrigerator Compartment may Melt

An LP gas leak increases the risk of a fire.

Potential Number of Units Affected: 8,161

Grand Design RV, LLC (Grand Design) is recalling certain 2017-2021 Solitude recreational trailers. The liquid propane (LP) supply line that runs through the exterior lower refrigerator compartment may contact the burner tube of the refrigerator, possibly damaging the line and causing an LP gas leak.

Grand Design will notify owners, and dealers will inspect the LP supply line for damage, replacing it as necessary. All lines in the vicinity of the burner tube will be wrapped in a thermal foil heat barrier material, then secured away from the burner tube of the refrigerator with additional P-clamps, free of charge. The recall is expected to begin September 30, 2020. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design’s number for this recall is 910021.

Forest River Inc.

Inverter Allows Too Much Current To 10 Gauge Wire

Overloaded wires may increase the risk of a fire.

Potential Number of Units Affected: 22

Forest River Inc. is recalling certain 2021 Berkshire BEA40C-380, BEA40E-380, BEA45A-450, and BEA45CA-450 motorhomes equipped with 3000-watt inverters. These inverters supply too much current to the 10 gauge Romex wire.

Forest River will notify owners, and dealers will replace the 3000-watt inverter with a 2800-watt inverter, free of charge. The recall is expected to begin October 14, 2020. Owners may contact Forest customer service at 1-754-533-5934. Forest’s number for this recall is 40-1225.

Hose Too Long For Exterior Griddle

Storing the griddle while it has an open flame can increase the risk of a vehicle fire.

Potential Number of Units Affected: 8

Forest River, Inc. (Forest River) is recalling certain 2021 Coachmen Catalina CAT261BHS-8 and CAT263BHSCKLE recreational trailers. The exterior griddle was built with a six foot hose, allowing the griddle to be stowed in the vehicle with an open flame.

None of the vehicles have been retailed yet. Forest River dealers will install a three foot LPG hose instead of the six foot one, free of charge. Owners may contact Forest River customer service at 1-574-825-4995. Forest River’s number for this recall is 103-1227.

Jayco Inc.
Electronic Control Center Circuit Board may Short

A damaged circuit board could increase the risk of a fire.

Potential Number of Units Affected: 166

Jayco, Inc. (Jayco) is recalling certain 2019-2020 Entegra Reatta and Jayco Embark and 2020 Entegra ReattaXL motorhomes. The electronic control center circuit board may be damaged from voltages over 17 volts, causing the components on the board to become damaged.

Jayco will notify owners, and dealers will install an additional circuit module to the existing component board to provide over-current protection, free of charge. The recall is expected to begin October 9, 2020. Owners may contact Jayco customer service at 1-800-517-9137. Jayco’s number for this recall is 9903518.

Keystone RV Company

Bedroom Window Does Not Have Proper Crank Handle

Without the narrow crank handle, the emergency exit may be difficult to open, impeding the ability to open the window and resulting in an increased risk of injury in the event of an emergency.

Potential Number of Units Affected: 130

Keystone RV Company (Keystone) is recalling certain 2020-2021 Dutchmen Yukon 399ML, 400RL and 410RD recreational trailers. The bedroom egress window has a black round knob installed rather than a narrow crank handle.

Keystone will notify owners, and dealers will remove the existing black round knob and replace it with a narrow crank handle, free of charge. The recall is expected to begin October 19, 2020. Owners may contact Keystone customer service at 1-866-425-4369. Keystone’s number for this recall is 20-386.

Tiffin Motorhomes Inc.

Steering Pinch Bolts Not Tightened Properly

A loose steering pinch bolt can result in a loss of steering control, increasing the risk of a crash.

Potential Number of Units Affected: 8

Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2020 Bus and Phaeton motorhomes. The steering pinch bolts may not have been properly tightened.

Tiffin will notify owners, and dealers will tighten the steering bolts to specification, free of charge. The manufacturer has not yet provided a schedule for recall notification. Owners may contact Tiffin customer service at 1-256-356-8661.

Daimler Trucks North America LLC

Engine Harness May Contact & Chafe

An engine stall can increase the risk of a crash.

Potential Number of Units Affected: 9,664

Daimler Trucks North America LLC (DTNA) is recalling certain 2018-2021 Freightliner 114SD, 108SD, and Business Class M2 vehicles. The engine harness wires may chafe at various locations around the air compressor and the frame rail. The damaged wires may short causing the engine to stall without any prior warning.

DTNA will notify owners, and dealers will inspect for adequate harness clearance and verify that the harness has not been damaged. Vehicles with a damaged harness will receive a new harness that consists of a severe duty wrapping and additional hardware. All repairs will be performed free of charge. The recall is expected to begin October 30, 2020. Owners may contact DTNA customer service at 1-800-547-0712. DTNA’s number for this recall is FL-860.

Tire Valve Stem Extension May Become Damaged

Extensive damage to the valve stem extension may result in a loss of tire pressure of the inner wheel, increasing the risk of a crash.

Potential Number of Units Affected: 10,359

Daimler Trucks North America LLC (DTNA) is recall certain 2018-2019 Freightliner Custom Chass XCL, 2018-2021 Freightliner XCM chassis, XCS Chassis and MC Chassis and 2017-2021 XCR Chassis. The tire valve stem extension for the inner wheel may come in contact with the outer wheel rim opening and become damaged.

The remedy for this recall is still under development. The recall is expected to begin October 30, 2020. Owners may contact DTNA customer service at 1-800-547-0712. DTNA’s number for this recall is FL-861.

Motor Coach Industries

Coolant Hose May Fail

The spilled coolant may increase the risk of a crash. Additionally, transferring passengers from the disabled bus can increase their risk of injury.

Potential Number of Units Affected: 1,561

Motor Coach Industries (MCI) is recalling certain 2017-2020 J4500 motor coaches. The coolant hose may fail, resulting in a low coolant warning followed by an engine shut down sequence, as well as the potential for engine coolant spilling on the roadway.

MCI will notify owners, and dealers will replace the coolant hose, free of charge. The recall is expected to begin October 23, 2020. Owners may contact MCI customer service at 1-800-241-2947. MCI’s number for this recall is SB 486.

PJ Trailers

Hydraulic Cylinder Attachment Bolts May Fail

Use of the dump box after the attachment bolts fail may result in a sudden drop of the box as it is being raised, increasing the risk of injury.

Potential Number of Units Affected: 694

PJ Trailers is recalling certain 2020-2021 DE trailers. The attachment bolts of the hydraulic cylinder may fail if the hydraulic system is used to lower the dump box once the dump box is already in the fully lowered position.

PJ Trailers will notify owners, and dealers will replace the hydraulic power unit and the attachment bolts, free of charge. The recall is expected to begin October 1, 2020. Owners may contact PJ Trailers customer service at 1-866-752-8781.

Gulf Stream

Front Trim Strip May Be Missing from Refrigerator

Without the front trim strip, carbon monoxide or flammable unburned Liquid Petroleum (LP) gases may migrate into the living quarters of the travel trailer, increasing the risk of fire or carbon monoxide poisoning causing occupant injury.

Potential Number of Units Affected: 32

Gulf Stream Coach, Inc. (Gulf Stream) is recalling certain 2020 Enlighten 25BH and 248BH travel trailers. The lower front trim strip may be missing from the refrigerator. The front strip is required to make the refrigerator cabinet seal complete, and provides complete isolation of the combustion system from the travel trailer interior.

Gulf Stream will notify owners, and dealers will inspect the trailers and verify that the seal at the bottom of the refrigerator cabinet is installed properly, free of charge. The recall is expected to begin in September 2020. Owners may contact Gulf Stream customer service at 1-800-289-8787. Gulf Stream’s number for this recall is 08282020.

Front Trim Strip May Be Missing from Refrigerator

Without the front trim strip, carbon monoxide or flammable unburned Liquid Petroleum (LP) gases may migrate into the living quarters of the travel trailer, increasing the risk of fire or carbon monoxide poisoning causing occupant injury.

Potential Number of Units Affected: 90

Gulf Stream Coach, Inc. (Gulf Stream) is recalling certain 2021 Enlighten 25BH travel trailers. The lower front trim strip may be missing from the refrigerator. The front strip is required to make the refrigerator cabinet seal complete, and provides complete isolation of the combustion system from the travel trailer interior.

All of the trailers affected by this recall have been repaired and owner letters will not be sent. Owners may contact Gulf Stream customer service at 1-800-289-8787. Gulf Stream’s number for this recall is 08312020.

RV News magazine spread
If you are employed in the RV industry and not a member of the trade media, Subscribe for Free:
  • Daily business news on the RV industry and the companies and people that encompass it
  • Monthly printed and/or digital magazine filled with in-depth articles to increase profit margins
  • Statistics, data and other RV business trade information
X
Scroll to Top